SpaceX’s Falcon Heavy could launch astronauts to the Moon, says NASA admin

Despite contrary comments made one week prior, NASA administrator Jim Bridenstine has affirmed – this time in no uncertain terms – that a two-week study investigating commercial options for launching the Orion spacecraft to the Moon has concluded that Falcon Heavy could be the only practical option if NASA chooses to proceed.

Due to fundamental performance and logistical constraints of both Delta IV Heavy and Falcon Heavy, as well as a lack in confidence in certain alternative paths, NASA now believes that a commercial option – Falcon Heavy – exists, but would face multiple major challenges, to the extent that Bridenstine indicated it would not be able to make the 2020 launch deadline with an unspecified budget. However, unlike his March 27th statements to Congress, he told the NASA stakeholder audience that the complex Falcon Heavy configuration “could be used in the future if [NASA can] get through all of [the challenges].” Reading between the lines, Administrator Bridenstine has effectively put the expensive and delay-ridden SLS rocket on notice if its contractors – primarily Boeing – fail to rise to the challenge and accelerate the rocket’s launch debut.

The April 1st comments – made before an audience of major NASA center leaders – are in stark contrast to dozens of comments made by Bridenstine in response to members of Congress on March 27th, in which he repeatedly went to bat for SLS launching Orion on EM-1 while scarcely mentioning commercial alternatives.

Despite the apparent incoherence of Administrator Bridenstine’s continuing comments, the sad – but also promising – reality of these displays can be summarized with one simple explanation: Bridenstine is a trained politician, not a trained bureaucrat. In other words, he is essentially playing his crowds and tweaking messages to better resonate with certain types of stakeholders. Relatively new for a NASA administrator, it remains to be seen whether his unfamiliar approach will produce serious results.

Sitting before the Senate Commerce, Science, and Transportation committee on March 13th, he announced the commercial Orion launch study as a token of recognition that NASA needs to get better at staying on-schedule and on-budget for US taxpayers and Congressional purse string-holders. After the US Vice President challenged NASA to return humans to the Moon with any means necessary by 2024, Bridenstine affirmed that NASA would do everything in its power to meet that charge, including the exploitation of commercial alternatives. In a March 27th hearing before members of Congress with explicit stakes in the SLS rocket’s pork, he barely mentioned commercial alternatives for Orion EM-1, instead focusing on a paired study aiming to accelerate the SLS launch debut schedule while also reiterating his confidence that Boeing and other contractors can rise to the occasion.

In his latest April 1st comments on commercial launch alternatives for Orion’s Moon mission debut, Bridenstine spoke to nearly all of NASA’s major center, program, and directive managers and stuck to the technical facts of the matters at hand. He repeatedly acknowledged that both launching an uncrewed Orion spacecraft to the Moon before the end of 2020 and returning astronauts to its surface by the end of 2024 would be extraordinary challenges and could require far-reaching changes and reforms throughout NASA. He also reaffirmed his intent to ensure that nothing be taken off the table as an option to accomplish those ambitious goals. This included an indication that (in more polite terms, of course) the spectre of Falcon Heavy would continue to hang over the heads of Boeing and the SLS program moving forward, a new and constant reminder that failure to be cost-efficient and stay on-schedule from now on could necessitate actions that would make SLS almost entirely redundant.

We see, in history, that in the past we have had an agenda to get to the Moon and then the resources don’t materialize and it gets canceled, and then we have another agenda to go to the Moon and the resources don’t materialize and it gets canceled. From my perspective, it is my objective to get the resources necessary to accomplish [this goal]. It is also my commitment to make sure that people understand the history here and that we can have a great, ambitious goal, but without the resources, it won’t be accomplished.

NASA Administrator Jim Bridenstine, 04/01/2019

“A whole host of challenges”

The specifics of what the NASA administrator briefly hinted at for a Falcon Heavy launch of EM-1 are spectacular enough to warrant additional discussion. According to Bridenstine, the two-week study NASA conducted essentially concluded that ULA’s Delta IV Heavy rocket was not a practical option for several major reasons. First, it seems that NASA has little to no confidence that Lockheed Martin and its contractors would be able to retrofit EM-1’s Orion and European Service Module (ESM) with the hardware and software needed for on-orbit rendezvous with a boost stage in time for a 2020 launch. Those capabilities were not planned for Orion until EM-3, NET 2024 in an absolute best-case scenario. This would entirely preclude a distributed launch solution, regardless of whether Delta IV Heavy is capable of placing the payloads in orbit.

Even if a rendezvous was on the table, a distributed launch scenario would still be impossible with either two Falcon Heavies or Delta IV Heavies, as both launches would have to occur as close to simultaneously as possible – optimally just a few hours apart. SpaceX has only one pad capable of supporting Falcon Heavy, while ULA’s Delta IV Heavy has two pads, but only one that can launch to the required orbit. A bigger problem: Delta IV Heavy is capable of launching no more than ~28,400 kg (63,000 lb) to an altitude of ~200 km (120 mi), which definitely rules out a Delta IV Heavy launch of the ICPS upper stage (~30,000 kg, 66,000 lb) and could also fall short for Orion/ESM (~26,000 kg, 57,000 lb), assuming that both would need to be launched to an elliptical orbit of 1800 km (1150 mi).

Due to NASA’s implied assumption that on-orbit rendezvous of Orion and a booster stage is out of the question and the potential performance shortcomings of Delta IV Heavy, as well as Falcon Heavy’s inability to launch Orion/ESM towards lunar orbit, only one option apparently remains. According to Bridenstine, NASA concluded that a mission profile in which Falcon Heavy places Orion, a service module, and an ICPS upper stage in orbit in a single launch may actually be a serious option – and the only option – for a near-term commercial alternative for Orion’s first operational test flight. The unofficial graphic above offers a rough glimpse of what that massive payload might look like atop Falcon Heavy.

[Finally], there is another solution out there: a Falcon Heavy with an ICPS at the top – talk about strange bedfellows – and an ESM and Orion crew capsule. That ultimately has the ability to potentially – gosh, [NASA Associate Administrator Bill] Gerst is gonna be so mad at me for saying all of this… by the way, none of this was cleared by Gerstenmaier, he’s still the best rocket scientist we have [camera pans to Gerst, laughter], no insult to anyone else in the room – so, at the end of the day, there is a solution here that could potentially work for the future.

It would require time, it would require cost, and there is risk involved, but guess what? If we’re gonna land boots on the Moon in 2024, we have time, and we have the ability to accept some risk and make some modifications. All of that is on the table. There is nothing sacred here that is off the table, and [FH+ICPS+Orion/ESM] is a potential capability that could help us land on the Moon in 2024.

NASA Administrator Jim Bridenstine, 04/01/2019

Combined, the Orion spacecraft, its ESM, and a fueled ICPS boost stage would weigh no less than 56,000 kg (~123,000 lb) at launch, relative to Falcon Heavy’s reported expendable performance of about 64,000 kg (140,000 lb) to Low Earth Orbit (LEO). In other words, it’s possible that Falcon Heavy could effectively do the exact same job as SLS would need to do to perform a nominal Orion EM-1 orbital insertion. However, a huge number of challenges remain for such an exotic Falcon Heavy configuration. Pad 39A would need to be outfitted with an array of systems, including a liquid hydrogen propellant plant and the ability to load Orion and its service module with hypergolic propellant while atop Falcon Heavy and vertical on the pad. To allow for vertical Orion/ESM/ICPS processing and fueling and support the massive weight and height (~95m vs. 70m) of the vehicle, the transporter-erector would need to be heavily modified. Additionally, Falcon Heavy’s aerodynamic characteristics would need to be entirely reanalyzed for such a significantly taller payload fairing.

But, as Bridenstine made clear above, those challenges would be par for the course of accomplishing something as audacious as returning humans to the Moon in less than six years. Whether or not NASA actually pursues or Congress funds such an alternative beyond the drawing board, the cat is now officially out of the bag. A potentially satisfactory replacement for SLS will now hang over the program’s head for the indefinite future, a constant threat in the (quite likely) event that the many SLS/Orion contractors fail – once again – to even loosely adhere to their budget and schedule targets. Falcon Heavy will be waiting.

Check out Teslarati’s newsletters for prompt updates, on-the-ground perspectives, and unique glimpses of SpaceX’s rocket launch and recovery processes.