SpaceX
SpaceX Falcon 9 rocket lands for the last time ahead of risky in-flight abort test
SpaceX’s latest successful launch and landing has wrapped up with Israeli Moon lander Beresheet on its way to Earth’s neighbor, Indonesian communications satellite PSN-6 headed to its final orbit, and the second thrice-flown Falcon 9 Block 5 booster safely returned to Port Canaveral aboard drone ship Of Course I Still Love You (OCISLY).
Known as Falcon 9 B1048, its third successful landing and recovery will almost certainly be this booster’s last after its fourth launch was officially assigned to a critical Crew Dragon launch abort test, one that the booster is very unlikely to survive. According to SpaceX CEO Elon Musk, that test could occur as early as April and will push the first flight-proven Crew Dragon space capsule to its limits.
https://twitter.com/_TomCross_/status/1099688043009753088
After weathering what Musk also described as the toughest reentry and heating conditions yet experience by a Falcon 9 booster meant for recovery, Falcon 9 B1048 landing (almost) flawlessly aboard drone ship OCISLY, stationed roughly 700 km (430 mi) off the Florida coast. Hinted at by the booster’s very slight lean on the recovery vessel’s deck, B1048 most likely cut thrust (or ran out of fuel) just before the optimal stop point, causing the rocket to fall a few unintended feet onto OCISLY and eat into part of the aluminum honeycomb ‘crush-core’ present on all Falcon landing legs.
Reentry, even at 1/4 of orbital speed is hard pic.twitter.com/Tk2KJblWH5
— Scott Manley (@DJSnM) February 22, 2019
In essence, that crushable aluminum acts as a very rough form of emergency suspension meant to minimize potential damage to the fragile structure of Falcon booster propellant tanks at the cost of its landing legs. In the case of B1048’s third landing, the lean appears to be no more than a few degrees – scarcely out of the ordinary, at least relative to past leaning boosters. Most notably, Falcon 9 B1023 experienced a similar anomaly and a far worse lean after its first landing, an experience that did not apparently impact its ability to launch for the second time as a side booster for Falcon Heavy’s inaugural launch.
-
- Falcon 9 B1048 returned to Port Canaveral on February 24th after its third successful launch and landing. (Teslarati)
-
- B1048.3 beside its human caretakers. (Tom Cross)
-
- Octagrabber robots are meant to prevent boosters from sliding off of drone ship decks by anchoring them with their tank-like weight. (Teslarati)
B1048’s slight departure from a perfect trajectory should thus pose no problem for in-place plans for the rocket’s fourth (and likely final) launch. Known as Crew Dragon’s in-flight abort (IFA) test, SpaceX specifically requested the inclusion of a second abort test (above and beyond NASA’s testing requirements) to fully verify that astronauts could be pulled to safety at any point during launch. In 2015, the company completed a pad abort test of Crew Dragon, demonstrating that the spacecraft could escape from a failing rocket while static on the launch pad. The in-flight abort is precisely what it sounds like: a demonstration that Crew Dragon can safely escape a failing rocket while in flight. More than simply being in flight, the goal is to demonstrate a successful abort at the point of peak aerodynamic stress of Falcon 9 and Dragon, known as Max Q.
For Cargo Dragon launches, Falcon 9 has typically averaged dynamic forces of about 25 kPa (~4 psi), roughly equivalent to 2.5 tons of force per square meter. During launch, either the payload fairing or Cargo/Crew Dragon are subjected directly to those forces, often requiring a significant period of lower throttle to mitigate the forces those sensitive assemblies experience. Given that Crew Dragon’s abort scenario accelerates the capsule and trunk from a relative speed of zero to nearly 350 mph (150 m/s) in five seconds, the dynamic forces (i.e. mechanical loads and heating) the spacecraft is experiencing could jump 50% or more almost instantaneously.
-
- Falcon 9 B1054 around the time of Max Q. (Tom Cross)
-
- While it doesn’t necessarily correlate with Max Q, vapor cones like the one on B1047’s fairing are a partial visualization of Max Q forces. (SpaceX)
-
- An official SpaceX render shows Falcon 9 and Crew Dragon lifting off from Pad 39A. (SpaceX)
-
- Falcon 9 B1051 and Crew Dragon vertical at Pad 39A. (SpaceX)
After Crew Dragon aborts, the Falcon 9 stack – featuring B1048 and a full-fidelity upper stage with a mass simulator in place of its MVac engine – will be instantaneously exposed to those same dynamic forces, experientially equivalent to bellyflopping from an Olympic-height diving platform. The upper stage may actually be better off than the booster thanks to the generally smooth dome at its stern, whereas Falcon 9’s booster would have its interstage – a deep, open cylinder – exposed to the same airflow if or when the upper stage is torn away. At the point of abort, Falcon 9 will most likely be in the process of shutting down its Merlin 1D engines, effectively removing the booster’s control authority and leaving it at the mercy of the atmosphere. SpaceX’s CRS-7 Cargo Dragon failure (caused by the second stage losing structural integrity mid-flight) is actually a decent representation of what is likely to happen to B1048 and its upper stage.
Given the potential destructive power B1048 will face, not to mention the fact that the booster will likely not have grid fins or landing legs installed, today’s recovery will probably be the last time the rocket returns to port and prepares for another launch. Explicitly dependent upon the refurbishment of DM-1’s Crew Dragon capsule, SpaceX’s in-flight abort is not expected to occur until June 2019, although Musk has indicated that the aspirational target is to perform the test as early as April, perhaps less than 60 days after the capsule is scheduled to land in the Atlantic Ocean.
Check out Teslarati’s newsletters for prompt updates, on-the-ground perspectives, and unique glimpses of SpaceX’s rocket launch and recovery processes!
TESLARATI Premium Membership
$19.99 USD
Elon Musk
Elon Musk just set a condition that could end Falcon 9 as we know it
Elon Musk says SpaceX will finally retire Falcon 9 once Starship flies reliably every week.
Elon Musk gave the clearest timeline yet for retiring Falcon 9, SpaceX’s workhorse rocket.
The comment came in a reply on X, where Musk wrote that “once Starship is flying reliably several times per week, it makes sense to shift super scarce SpaceX engineering and production resources to Starship to get launch rate to several times per day, which means winding down Falcon.” He was responding to physicist Casey Handmer, who noted that NASA is reportedly uneasy about SpaceX phasing out Falcon after building what Handmer called the most successful launcher ever, with the fleet nearing 1,000 total launches.
Now @SciGuySpace reports NASA is in a tizzy because after running the most successful launcher ever for more than a decade and nearing 1000 launches, @SpaceX is planning to retire Falcon in favor of Starship in a few years.
Sorry, NASA, you’ve had 15 years to burn down the… https://t.co/uCNoMwK0v9
— Casey Handmer (@CJHandmer) August 22, 2026
Falcon 9 is still SpaceX’s busiest vehicle by far. The company is on pace for roughly 140 to 145 Falcon flights this year, following 165 in 2025, president Gwynne Shotwell told Time earlier in 2026. She has already said Falcon flights would “tail off” as Starship comes online, while reports indicate that SpaceX has stopped booking new Falcon 9 launches past 2028 and halted production of some expendable Falcon hardware, according to Bloomberg.
It’s worth noting that Musk’s post is a condition, and not a countdown on when Falcon will retire. Starship has not yet flown weekly, let alone daily. Its most recent flight in July ended with a soft splashdown in the Indian Ocean, a milestone Musk pointed to earlier this month when he said the vehicle’s heat shield problem was effectively solved. SpaceX towed that ship to Christmas Island for inspection, and the next flight, Flight 14, is aimed at putting Starship into orbit for the first time. A tower catch attempt for the upper stage has been pushed back to what Musk has called “a few months” away.
SpaceX and a new Trump order that could rewrite the next decade of launches
The gap between Falcon’s role today and Starship’s promised role tomorrow matters most to NASA. Falcon and its Dragon capsule remain the only way the agency rotates astronauts to and from the International Space Station, and Starship is not certified to carry NASA crews. Musk’s post did not address how that handoff would work if Falcon winds down before a crew-rated Starship variant exists. The timing lines up with Musk’s other recent Starship comments. Two days before the Falcon post, he told a different X user that SpaceX is aiming for more than 30 Starship launches a day by 2030, or roughly 10,000 a year, a figure tied to the Trump administration’s new push for higher national launch cadence. Falcon, which took over a decade to reach its first 100 launches, was never built to approach that kind of volume.
For now, Falcon 9 keeps flying at a near-record pace while Starship works to prove it can do the job Musk has already picked out for it.
Elon Musk put a number on where he thinks SpaceX’s Starship program is headed by 2030, replying on X a day after President Trump signed a memo pushing the country toward 1,000 space launches and reentries a year.
The exchange started when Aaron Burnett, co-founder of propulsion startup Mach 33, posted that “1,000 launches/reentries is the goal,” quoting White House science adviser Michael Kratsios on the newly signed National Space Transportation Policy. Burnett noted that the FAA’s own bull-case forecast reached only 385 annual launches by 2030, while his firm’s conservative model already put SpaceX alone near 940. Musk responded, “We’re aiming to reach 30+ Starship launches/day in 2030, which is ~10k annualized. Still tiny numbers compared to airplane flights!”
We’re aiming to reach 30+ Starship launches/day in 2030, which is ~10k annualized.
Still tiny numbers compared to airplane flights!
— Elon Musk (@elonmusk) August 21, 2026
That figure is specific to Starship, the rocket SpaceX is still developing for orbital and lunar missions, not the Falcon 9 fleet that carries most of the company’s current launch volume. Starship has flown twice this year, a slower pace than the four and five flights SpaceX managed in 2024 and 2025. Getting from two flights a year to 30 a day is the scale of jump the new federal policy is meant to clear regulatory room for.
Trump’s memo, signed Thursday, directs agencies to identify new launch and reentry sites on federal land, including a new reentry site within 90 days, and to speed up the permitting and environmental reviews that have long slowed cadence growth. It also sets a goal of returning American astronauts to the moon by 2028 and placing initial lunar base elements by 2030, tying the launch buildout directly to NASA’s Artemis program.
SpaceX has already been pushing the FAA toward higher numbers on its own. The agency approved up to 44 annual Starship launches from Kennedy Space Center in February, on top of a 2024 review that raised the cap at Starbase in Texas to 25 a year. Those approvals cover a fraction of the 10,000 annual flights Musk is now describing, which shows how far current permitting still sits from the administration’s stated target.
The near-term test of all this is more modest. SpaceX cleared a full-duration, six-engine static fire on its next Starship vehicle this week, the last major hardware checkpoint before Flight 14, which is targeting no earlier than August 28 and is expected to attempt the vehicle’s first full orbital mission. Musk said last week that a tower catch of the upper stage is still probably months away, a reminder that the immediate roadmap remains far more incremental than the daily launch numbers he just posted.
SpaceX CEO Elon Musk announced today that the company will likely attempt to catch the Starship upper stage with its launch tower arms “in a few months.”
In a post on X, Musk wrote, “Looks like we will probably catch the ship with the tower in a few months. If there had been a tower out to sea where we practiced landing the ship, it would have been caught.” He added that the first reflight of a Starship vehicle is expected by the end of 2026 or early 2027, describing it as “a fork in the road of history for consciousness reaching the stars.”
Looks like we will probably catch the ship with the tower in a few months. If there had been a tower out to sea where we practiced landing the ship, it would have been caught.
First reflight of the ship will be either end of this year or early next. That will be a fork in the… https://t.co/O5g9pqrzyo
— Elon Musk (@elonmusk) August 20, 2026
Musk’s prediction comes amid ongoing progress toward full reusability of the Starship system, a two-stage rocket designed for rapid turnaround and dramatically lower launch costs. Catching the upper stage, known simply as “ship,” with the Mechazilla tower’s mechanical arms would mark a major milestone. It would allow both stages to return directly to the launch site for quick refurbishment and reuse, eliminating the need for ocean recovery.
Musk has previously signaled plans for a ship catch. In July, shortly after SpaceX’s wildly successful Starship 13 mission, he stated that the company would attempt to catch the ship with the tower on the next flight unless problems emerged in the mission data review. Earlier comments also outline conditions such as successful soft ocean landings before attempting a land recovery to minimize risk.
SpaceX has solved Starship’s biggest challenge, Elon Musk says
The latest update from Musk adjusts this timeline to a few months, reflecting the iterative nature of the test campaign.
SpaceX has already demonstrated the tower catch technique successfully with the Super Heavy booster on a couple of occasions. The first successful booster catch occurred during Flight 5 in October 2024, when the massive first stage returned to the Starbase pad in Texas and was plucked from the air by the tower arms.
Additional catches followed on later flights, including Flight 7, proving the concept for the booster and building confidence in the system as a whole.
Achieving a similar catch for the upper stage would represent a significant step forward. The ship returns from much higher speeds and greater heat loads after orbital or near-orbital flight. Success would advance SpaceX’s goal of full and rapid reusability, potentially reducing the cost of access to orbit by a factor of 100 or more and supporting ambitions for frequent satellite deployments, lunar missions, and eventual Mars flights.
Musk has long emphasized that true reusability, refueling rather than discarding hardware, is essential for making humanity a multi-planetary species.
As SpaceX continues refining Starship through successive test flights, the coming months will test whether the ambitious catch timeline can be met. The combination of prior booster successes and improving ship landing precision suggests the company is steadily closing in on this historic capability.
Tesla Semi factory is getting a celebration nobody expected
Elon Musk just set a condition that could end Falcon 9 as we know it
