News
SpaceX Starship prototype charred but intact after catching fire [photos]
SpaceX teams have finally safed the fourth full-scale Starship prototype nearly two days after a Raptor engine test caught it on fire, an anomaly that left the massive rocket charred and damaged – but still intact.
While SN4’s survival is a welcome and unexpected outcome, the fire that broke out near the base of the rocket caused damage that will have to be repaired, while the fault that allowed that fire to occur in the first place will also need to be rectified. Had the same events transpired during the ship’s inaugural flight test, things could have gone even further south after the rocket lifted off, carrying it away from remotely-controlled water jets used to suppress unplanned fires on the pad.
Thankfully, SpaceX’s focus on testing, testing, and testing some more meant that Starship SN4’s minor self-immolation occurred on the ground when the stakes – while high – were much lower than they would have been with an airborne rocket. The problems uncovered will, of course, need to be fixed, inevitably delaying the ship’s first flight test, but odds are that SN4 now has a better shot at success thanks to those hiccups.
Thanks to the fact that Starships are constructed almost entirely out of steel, a little (or a lot of) fire shouldn’t theoretically be much of a problem. However, SpaceX has taken a rather freeform approach to its early Starship SNx prototypes, opting to bolt, weld, or tape on the vast majority of external hardware with little or no protection from the elements, including fires ignited by the ships themselves.
With SN4, it appears that the pressure jump experiences immediately after Raptor ignition (the ship’s third such test) shook some methane-related plumbing loose. Raptor continued to burn for another five or so seconds after that minor failure, shutting down as planned – but not before it ignited the methane the burst pipe was leaking. Additionally, after that new plume of boiling liquid methane caught fire, the fire it sustained proceeded to ignite insulation wrapped around the rocket’s launch. It burned vigorously, likely helping to damage wiring, ultimately causing SpaceX to partially lose control of the rocket and preventing attempts to inspect and fix the damage for two full days.
It’s safe to say that SpaceX is probably going to prioritize avoiding the series of events that caused May 19th’s anomaly from here on out, considering that things could have easily gone much worse. Thankfully, whatever control SpaceX or the rocket itself retained after wire damage allowed it to safely offload its flammable propellant and vent expanding gases to prevent SN4’s tanks from bursting. Installing highly flammable insulation approximately 10 feet away from an active Raptor engine and giant controlled fire and explosion was also inadvisable and probably won’t be repeated.
Thankfully, the damage is clearly minimal and Starship SN4 survived the ordeal otherwise unscathed. With any luck, inspections and repairs will be quick and easy and SpaceX – as NASASpaceflight reporter Michael Baylor notes – will be able to complete an identical static fire test without starting a fire on Starship SN4. SpaceX has requested a new road closure (signifying planned testing) on May 28th with backup windows on May 29th and June 1st.
Thanks to Starship SN4’s unplanned delays, it now looks quite likely that SpaceX’s next full-scale Starship prototype (SN5) will be completed – or nearly so – by the time that its predecessor is cleared for flight. “Too many Starships” is certainly a welcome problem to have.
News
Tesla wins top loyalty and conquest honors in S&P Global Mobility 2025 awards
The electric vehicle maker secured this year’s “Overall Loyalty to Make,” “Highest Conquest Percentage,” and “Ethnic Loyalty to Make” awards.
Tesla emerged as one of the standout winners in the 2025 S&P Global Mobility Automotive Loyalty Awards, capturing top honors for customer retention and market conquest.
The electric vehicle maker secured this year’s “Overall Loyalty to Make,” “Highest Conquest Percentage,” and “Ethnic Loyalty to Make” awards.
Tesla claims loyalty crown
According to S&P Global Mobility, Tesla secured its 2025 “Overall Loyalty to Make” award following a late-year shift in consumer buying patterns. This marked the fourth consecutive year Tesla has received the honor. S&P Global Mobility’s annual analysis reviewed 13.6 million new retail vehicle registrations in the U.S. from October 2024 through September 2025, as noted in a press release.
In addition to overall loyalty, Tesla also earned the “Highest Conquest Percentage” award for the sixth consecutive year, highlighting the company’s continued ability to attract customers away from competing brands. This achievement is particularly notable given Tesla’s relatively small vehicle lineup, which is largely dominated by just two models: the Model 3 and Model Y.
Ethnic market strength and conquest
Tesla also captured top honors for “Ethnic Market Loyalty to Make,” a category that highlighted especially strong retention among Asian and Hispanic households. According to the analysis, Tesla achieved loyalty rates of 63.6% among Asian households and 61.9% among Hispanic households. These figures exceeded national averages.
S&P Global Mobility executives noted that loyalty margins across categories were exceptionally narrow in 2025, underscoring the significance of Tesla’s wins in an increasingly competitive market. Joe LaFeir, President of Mobility Business Solutions at S&P Global Mobility, shared his perspective on this year’s results.
“For 30 years, this analysis has provided a fact-based measure of brand health, and this year’s results are particularly telling. The data shows the market is not rewarding just one type of strategy. Instead, we see sustained, high-level performance from manufacturers with broad portfolios. In the current market, retaining customers remains a critical performance indicator for the industry,” LaFeir said.
Elon Musk
Elon Musk’s lawsuit against OpenAI and Microsoft is heading to jury trial
The ruling keeps alive claims that OpenAI misled the Tesla CEO about its charitable purpose while accepting billions of dollars in funding.
OpenAI Inc. and Microsoft will face a jury trial this spring after a federal judge rejected their efforts to dismiss Elon Musk’s lawsuit, which accuses the artificial intelligence startup of abandoning its original nonprofit mission. The ruling keeps alive claims that OpenAI misled the Tesla CEO about its charitable purpose while accepting billions of dollars in funding.
As noted in a report from Bloomberg News, a federal judge in Oakland, California, ruled that OpenAI Inc. and Microsoft failed to show that Musk’s claims should be dismissed. U.S. District Judge Yvonne Gonzalez Rogers stated that while the evidence remains unclear, Musk has maintained that OpenAI “had a specific charitable purpose and that he attached two fundamental terms to it: that OpenAI be open source and that it would remain a nonprofit — purposes consistent with OpenAI’s charter and mission.”
Judge Gonzalez Rogers also rejected an argument by OpenAI suggesting that Musk’s use of an intermediary to donate $38 million in seed money to the company stripped him of legal standing. “Holding otherwise would significantly reduce the enforcement of a large swath of charitable trusts, contrary to the modern trend,” Judge Gonzalez Rogers wrote.
The judge also declined to dismiss Musk’s fraud allegations, citing internal OpenAI communications from 2017 involving co-founder Greg Brockman. In an email cited by the judge, fellow OpenAI board member Shivon Zilis informed Musk that Brockman would “like to continue with the non-profit structure.”
Just two months later, however, Brockman wrote in a private note that he “cannot say that we are committed to the non-profit. don’t want to say that we’re committed. if three months later we’re doing b-corp then it was a lie.”
Marc Toberoff, a member of Musk’s legal team, said Judge Gonzalez Rogers’s ruling confirms that “there is substantial evidence that OpenAI’s leadership made knowingly false assurances to Mr. Musk about its charitable mission that they never honored in favor of their personal self-enrichment.”
OpenAI, for its part, maintained that Musk’s legal efforts are baseless. In a statement, the AI startup said it is looking forward to the upcoming trial. “Mr. Musk’s lawsuit continues to be baseless and a part of his ongoing pattern of harassment, and we look forward to demonstrating this at trial. We remain focused on empowering the OpenAI Foundation, which is already one of the best-resourced nonprofits ever,” OpenAI stated.
News
Tesla arsonist who burned Cybertruck sees end of FAFO journey
The man has now reached the “Find Out” stage.
A Mesa, Arizona man has been sentenced to five years in federal prison for setting fire to a Tesla location and vehicle in a politically motivated arson attack, federal prosecutors have stated.
The April 2025 incident destroyed a Tesla Cybertruck, endangered first responders, and triggered mandatory sentencing under federal arson laws.
A five-year sentence
U.S. District Judge Diane J. Humetewa sentenced Ian William Moses, 35, of Mesa, Arizona, to 5 years in prison followed by 3 years of supervised release for maliciously damaging property and vehicles by means of fire. Moses pleaded guilty in October to all five counts brought by a federal grand jury. Restitution will be determined at a hearing scheduled for April 13, 2026.
As per court records, surveillance footage showed Moses arriving at a Tesla store in Mesa shortly before 2 a.m. on April 28, 2025, carrying a gasoline can and backpack. Investigators stated that he placed fire starter logs near the building, poured gasoline on the structure and three vehicles, and ignited the fire. The blaze destroyed a Tesla Cybertruck. Moses fled the scene on a bicycle and was arrested by Mesa police about a quarter mile away, roughly an hour later.
Authorities said Moses was still wearing the same clothing seen on camera at the time of his arrest and was carrying a hand-drawn map marking the dealership’s location. Moses also painted the word “Theif” on the walls of the Tesla location, prompting jokes from social media users and Tesla community members.
The “Finding Out” stage
U.S. Attorney Timothy Courchaine noted that Moses’ sentence reflects the gravity of his crime. He also highlighted that arson is never acceptable.
“Arson can never be an acceptable part of American politics. Mr. Moses’ actions endangered the public and first responders and could have easily turned deadly. This five-year sentence reflects the gravity of these crimes and makes clear that politically fueled attacks on Arizona’s communities and businesses will be met with full accountability.”
Maricopa County Attorney Rachel Mitchell echoed the same sentiments, stating that regardless of Moses’ sentiments towards Elon Musk, his actions are not defensible.
“This sentence sends a clear message: violence and intimidation have no place in our community. Setting fire to a business in retaliation for political or personal grievances is not protest, it is a crime. Our community deserves to feel safe, and this sentence underscores that Maricopa County will not tolerate political violence in any form.”
Tesla wins top loyalty and conquest honors in S&P Global Mobility 2025 awards
Elon Musk’s lawsuit against OpenAI and Microsoft is heading to jury trial
