News
Toyota bZ4X production to resume after fixing loose wheel recall, new airbag issue
Toyota Motor Corp. noted on Thursday that it would be resuming the production of its all-electric crossover and Model Y fighter, the bZ4X. The Japanese automaker revealed that it had found a resolution for the vehicles’ safety issues, which have caused the bZ4X’s sales to be suspended for more than three months.
Toyota recalled about 2,700 bZ4X units in June after learning that the vehicle’s wheels may come off while it’s operating on the road. A recall notice sent to Japan’s transport ministry indicated that sharp turns and sudden braking in the bZ4X might cause a hub bolt to loosen, raising the danger of a wheel falling off.
So notable were the safety issues of the bZ4X that Toyota asked owners of the all-electric crossover to stop driving their cars until a resolution to the recall could be found. Eventually, bZ4X owners in the United States shared communication from Toyota, which indicated that the company was already open to the idea of repurchasing the vehicle.
The bZ4X’s sister unit, the Subaru Solterra, was also recalled for the same issue. However, the problem was not too notable for Subaru as deliveries of the Solterra were yet to begin. Toyota, on the other hand, had already delivered the bZ4X to customers in several countries before the vehicle’s safety issues were discovered.
As noted in an Autoblog report, a filing from Toyota stated that the company would make sure hub bolts on the bZ4X were replaced and properly tightened moving forward. Interestingly enough, Toyota also revealed that it had actually identified another safety issue in the bZ4X — this time with the vehicle’s airbags.
Since some airbags were not properly installed at the factory, the bZ4X’s airbag units risk failure. They may also result in injuries due to the placement of a strap inside the airbag assembly. This issue has not been disclosed by the Japanese automaker previously, though Chief Technology Officer Masahiko Maeda noted that the company had been aware of the bZ4X’s airbag problems in the last month or so.
“We apologize again for the concern, anxiety, and inconvenience we have caused to our customers, our dealers, and our stakeholders,” Maeda said.
With the bZ4X now restarting production, customers in Japan can lease the vehicle again starting October 26, 2022. It should be noted that the bZ4X is only available for lease in Japan. Maeda, however, did not indicate when sales of the Model Y fighter in territories such as the United States would be resuming.
Don’t hesitate to contact us with news tips. Just send a message to simon@teslarati.com to give us a heads up.
A Tesla Semi caught fire in Hayward, California, which caused both directions of traffic to shut down for hours before being completely reopened early on Wednesday, the California Highway Patrol said.
The fire occurred just after 5:30 local time in Hayward on Tuesday, as the Semi caught fire in the southbound lanes of I-880 before CHP officials made the decision to shut down both lanes of traffic due to potential risks from hazardous chemical smoke.
There were no injuries reported.
🚨 A Tesla Semi reportedly caught fire, with California Highway Patrol confirming. The Semi was on I-880 SB
An estimated 5,000 to 7,000 semi-truck and large commercial vehicle fires occur on U.S. roadways every year
— TESLARATI (@Teslarati) October 28, 2026
The cause of the fire is currently unknown, as neither Tesla nor the CHP have not determined a cause.
However, some images taken before the Semi was completely destroyed by the fire seem to indicate this might have been an older unit, as it appears to be one of the designs that Tesla shipped as part of its pilot program, before revising it and starting mass production just a month ago.
@Tslachan From on of the videos looks like it’s an old Semi (not the refresh version that recently started production) https://t.co/KzwmR2kXow
— Area Under The Curve 🎗️ (@AreaUnderCurve) October 28, 2026
At the time of publication, CHP had not returned our request for a comment for additional details, including the Semi involved and any potential collaboration on an investigation between the CHP and Tesla. We will update this story when we hear back from them.
The southbound lanes were reopened at 3:30 a.m. on Wednesday, with the northbound lanes opening last night a few hours after the fire began. The CHP did state that the lithium batteries were “incredibly difficult to extinguish,” according to NBC Bay Area.
The truck’s driver said that the Semi caught fire, but he did not have an explanation.
An estimated 5,000 to 7,000 semi-truck and large commercial vehicle fires occur on U.S. roadways every year.
Tesla’s launch of the “Emergency Drive Away” function a few months back offered owners a safe option to evacuate an area if they were in reasonable danger. The function finally got its first use in the real world, but it appears it was by mistake.
A video shared by u/Joshalander in the r/TeslaLounge subreddit recorded the instance from his vehicle and said the incident took place in Austin this past weekend during the city’s F1 Race.
“Was charging around 6 AM this past Sunday in Austin before heading to the F1 race and heard a pop. Looked over and saw the new emergency drive-away feature in action. Genuinely felt bad for the dude when he got out and realized what happened, since he looked exhausted and only seemed to half-read the prompts.”
🚨 Here’s the first look at Tesla’s Emergency Drive Away function in action:
Apparently this driver accidentally enabled it and drove forward; you can see the Supercharger pull with the car.
Tesla said previously this would cost up to $25k if not used properly. https://t.co/B4qQRrsO6B
— TESLARATI (@Teslarati) October 28, 2026
Emergency Drive Away unlatches the Supercharger connector from the vehicle, but still causes damage to both the car and the Supercharger. Tesla has said that it will cost up to $25,000 in repairs to have everything fixed back to normal.
Additionally, the company said that if it were not used in an emergency situation, the driver of the vehicle who activated the Emergency Drive Away feature would be responsible for all repair costs.
Tesla constitutes the following situations as reasonable justifications for activating the feature:
- You face an immediate threat to your life or personal safety.
- You must leave the area immediately.
- Exiting the vehicle is unsafe.
- Unplugging the charge connector would unreasonably delay your departure or expose you to a risk to your personal safety.
After using the feature, Tesla requires the driver to schedule Service so the car can be inspected.
News
Tesla’s Cybercab battery design could make robotaxis even cheaper
Tesla built the Cybercab’s battery pack with spare room for a future switch to LFP.
Tesla built the Cybercab’s battery pack with empty space inside it on purpose, and the reason points to a cheaper robotaxi down the road.
Robert Sumpf, Tesla’s director of mechanical design engineering for battery modules and packs, said the extra room beside and beneath the Cybercab’s modules was left there so the company can move to lithium iron phosphate cells later. “So, we protected this pack to go to an even lower energy dense chemistry as we scale and need to bring LFP into the platform,” Sumpf said in a Cybercab deep dive with Munro Live.
The Cybercab runs on Tesla’s own 4680 cells with a nickel chemistry today. LFP cells store less energy for their size, so a straight swap would cut range. The reserved space lets Tesla add more LFP cells to make up the difference. In return, Tesla would get cells that cost less, run cooler and survive more charge cycles. LFP became the most used EV battery chemistry in the world last year.
Not all of that room was planned for a chemistry change. Lars Moravy, Tesla’s Vice President of Vehicle Engineering, said part of it exists because “we didn’t need as many batteries as we thought we did.” Tesla told Sandy Munro in early 2025 that it was targeting a Cybercab pack under 50 kWh with close to 300 miles of range.
The pack also breaks from the structural design Tesla used in some Model Y and Cybertruck builds. Instead of potting hundreds of cells into one block, the Cybercab uses four separate, individually sealed modules, so a bad module can be replaced without scrapping the whole pack. Sumpf was blunt about the older approach, giving the Model Y structural battery “a grade D” because it was hard to build and nearly impossible to repair. He estimated a fully structural pack gains about 10% more cell volume, but said “the issue is the service cost.”
That cost matters more for a car that rarely sits parked. Cybercab chief engineer Eric Earley said replacing an entire pack “before half a million miles is a killer on cost,” which is why remanufacturing and serviceability were built into the design from the start.
The same Munro Live tour produced Moravy’s admission that the Cybercab line at Giga Texas is now outpacing Robotaxi deployments, along with a look at the robotaxi’s unorthodox paint process. Tesla is aiming to deliver the first Cybercabs to outside customers by the end of 2026, though Elon Musk has said the vast majority will stay owned by Tesla and run as a transport service.
Sumpf did not give a date for an LFP version, name a cell supplier or say how a chemistry change would affect range. For now, the 4680 cars keep piling up: Texas DMV records from Tuesday list 544 Cybercabs authorized for Tesla’s Robotaxi fleet, more than the 507 Model Ys on the same roster for the first time.
Tesla Semi catches fire in California: what we know
Tesla’s ‘Emergency Drive Away’ function gets its first use in the real world
