Connect with us

SpaceX

SpaceX CEO Elon Musk says Starlink launch will reuse Falcon Heavy’s fairing

SpaceX CEO Elon Musk revealed that the company successfully recovered both Falcon Heavy fairing halves intact and plans to reuse them later this year. (SpaceX/Elon Musk)

Published

on

SpaceX CEO Elon Musk has revealed that the company successfully recovered both Falcon Heavy Flight 2 fairing halves intact and plans to reuse them this year on an operational Starlink launch.

This will be SpaceX’s first attempt to reuse Falcon payload fairings, a capability that could ultimately save up to 10% – around $6M – and countless production time per launch. Intriguingly, the Falcon Heavy fairing halves were recovered without the use of dedicated recovery vessel Mr. Steven – the vessel has been out of commission for months after an accident ripped off two of its four arms. Instead, the fairing halves parasailed to a soft ocean landing where SpaceX recovery experts aboard GO Searcher and GO Navigator carefully extracted both halves from the surface of the Atlantic. In order to reuse the fairing halves, SpaceX will need to somehow solve – if they haven’t already – the challenge of cleaning contaminated fairings.

How To Clean Your Fairing

The challenge of reusing payload fairings that have been some combination of immersed and thoroughly coated with salt water is by no means an easy one, evidenced primarily by the fact that no company or space agency has yet to try. As a temporary part of a rocket’s uppermost stage, every kilogram of weight present on the fairing can have an almost equally deleterious effect on that same rocket’s ability to place payloads in orbit. This is why the added complexity of additional deployable fairing mechanisms is universally accepted – by jettisoning fairings as soon as possible, rockets are able to carry significantly more payload to a given orbit.

This means that adding even more weight and complexity to fairings – optimized to be extraordinarily light for their often massive sizes – is avoided with extreme prejudice. This is the problem SpaceX faces in its quest to reliably recover and reuse fairings – how does one take fragile objects landing in the middle of the ocean after traveling no less than two kilometers per second (~1.2 mi/s) at apogees upwards of 100 km (62 mi) and prevent them from being destroyed, all while keeping them as light as possible?

SpaceX’s solution was to attach GPS-guided parafoils to each fairing half, as well as cold gas thrusters that allow the halves to orient themselves and remain stable between separation and parafoil deployment. Part two of that solution was to quite literally catch those floating halves out of the air with a giant, speedy boat outfitted with an equally giant net held up by four arms. Despite 5+ catch attempts and many, many controlled drop tests, that vessel – Mr. Steven – has never managed to successfully catch a Falcon fairing half. In early 2019, SpaceX moved the ship from California to Florida due to a launch drought facing the company’s West Coast launch facilities. Less than two weeks after arriving in Florida, an unknown accident resulted in the vessel losing both its net and two of its four arms to the sea, and Mr. Steven has since remained inactive – aside from infrequent trips out and about – in Port Canaveral.

Mr. Steven returned to Port of San Pedro around on October 8th after a day spent at sea, apparently with a Falcon fairing half in tow. This is the second known time that a fairing has been in Mr. Steven's net. The fairing was eventually lifted off around noon the following day.
Iconic fairing recovery vessel Mr. Steven seen shortly after an October 2018 series of controlled fairing drop tests. The fairing was likely placed manually in the net. (Pauline Acalin)

Judging from CEO Elon Musk’s twofold declaration that SpaceX will now reuse its first Falcon fairings without any involvement from Mr. Steven, it’s safe to say that success will sadly bring about the end of the leased fairing recovery vessel’s utility to SpaceX. However, there is a chance that this is not the case.

The fact that SpaceX is choosing to reuse a partially waterlogged fairing for the first time on an internal Starlink internet satellite launch suggests that whatever the solution may be, it may not be compatible – or at least kosher – with current industry standards. All prior reusability milestones have been tested on commercial launches after some sort of private agreement with the customers involved, including the first Falcon 9 booster reuse and the first instances of the same booster being launched for the third time. This is likely not fair to SpaceX or its excellent customers, though. The simpler explanation is that testing unproven technologies and hardware solutions on internal launches fundamentally minimizes the risk conveyed to paying customers that likely can’t afford to lose their spacecraft.

Workers process Falcon 9 B1046 after the booster’s third flawless launch and landing in seven months. (Pauline Acalin)
Mr. Steven was captured performing tests with a duo of fairings and nets at its Port of LA berth, January 22nd. (Pauline Acalin)
Double the fairings, double the fun! (Pauline Acalin)

There remains one additional explanation: SpaceX’s solution for reusing waterlogged fairings is, in fact, too immature or is an unacceptable risk of contamination for customers relative to industry standards of design. Instead, SpaceX may have chosen to build some sort of contamination resistance into the clean-slate design of its Starlink satellites, something that would be impractical to expect of customers who have spacecraft that are either already designed or built. Redesigning – let alone rebuilding – complex systems is an extremely costly endeavor. However, wide-reaching changes are far easier to implement when starting from a functionally blank page, exactly where SpaceX is with its first-generation Starlink satellites. As such, SpaceX may have decided to do just this after it realized that catching fairings could be far harder than expected and would thus remain a major bottleneck for Starlink launches if left unsolved.

Finally, it’s unclear if Musk is referring to the very first operational Starlink launch – scheduled as early as May 2019 – or an additional follow-on mission later this year. Refurbishing and reflying fairings for the first time in just one month would be an extremely impressive achievement but may also be an impractical schedule for pathfinder technology development. For now, this serves as a reminder that SpaceX’s first operational Starlink launch is scheduled one month from now.

Check out Teslarati’s Marketplace! We offer Tesla accessories, including for the Tesla Cybertruck and Tesla Model 3.

Eric Ralph is Teslarati's senior spaceflight reporter and has been covering the industry in some capacity for almost half a decade, largely spurred in 2016 by a trip to Mexico to watch Elon Musk reveal SpaceX's plans for Mars in person. Aside from spreading interest and excitement about spaceflight far and wide, his primary goal is to cover humanity's ongoing efforts to expand beyond Earth to the Moon, Mars, and elsewhere.

Advertisement
Comments

Elon Musk

Elon Musk spotlights the Starlink rescue that got through where no cell tower could

Elon Musk spotlighted how Starlink helped rescuers reach five people stranded in Kazakhstan’s snowy mountains.

Published

on

By

Elon Musk put a spotlight on a mountain rescue in eastern Kazakhstan on Sunday, writing “Starlink saves lives” in response to a post describing how SpaceX’s satellite internet helped five stranded people reach emergency crews.

The post from DogeDesigner, which had been viewed more than 500,000 times by Sunday afternoon, said the group’s SUV broke down about 15 kilometers from the village of Kystau Kurchum in an area with no usable mobile network. Starlink carried their call for help and kept them in contact with rescuers, who used the connection to locate them.

The rescue itself took place in October. Local outlet YK.kz reported on October 22 that Kazakhstan’s Ministry of Emergency Situations responded to the breakdown in the Kurchum district of East Kazakhstan region and noted that the group stayed in touch through Starlink. Rescuers covered roughly 100 kilometers in a Trekol, a low pressure tire vehicle built for snow and marshland, then escorted the disabled SUV back to Kystau Kurchum. Nobody needed medical attention.


Conditions in the region were rough at the time. Kazakh broadcaster Channel 7 identified the five as hunters caught in a snow trap and said satellite communication allowed rescuers to pinpoint where they were. A spokesperson for the East Kazakhstan emergency department said a storm warning was in effect and urged residents not to leave populated areas unless necessary. The same weather stranded seven utility workers repairing power lines in the nearby Kuygan rural district, according to Tengrinews.

Kazakhstan has been one of Starlink’s more notable markets in Central Asia. Teslarati reported in 2024 that Starlink was serving 1,731 of the country’s 1,879 schools, with the country’s Education Minister saying it had set a new standard for internet service in schools.

Rescue stories like this one have followed Starlink for years, usually in places where ground networks fail or never existed in the first place. Then Florida CFO Jimmy Patronis called Starlink a “game changer” for search and rescue crews during Hurricane Milton, and SpaceX and T-Mobile switched on Starlink Direct to Cell in North Carolina to push emergency alerts to phones after Hurricane Helene.

The next target is dead zones for people who do not carry a dish at all. SpaceX is building out Starlink Mobile and earlier this week selected Qualcomm to supply core infrastructure for a planned terrestrial 5G network in the United States, which it intends to pair with its next generation satellite constellation.

Sunday’s post is at least the third time Musk has written “Starlink saves lives” on X this week, following identical posts on November 5 and November 7.

Continue Reading

Elon Musk

SpaceX will perform Starship double catch attempt with Flight 15

Published

on

Credit: SpaceX

SpaceX plans to attempt what will be a defining moment in rocket reusability on Starship Flight 15.

As Elon Musk announced in a recent X post, SpaceX will attempt to catch both the Super Heavy Booster and the Starship upper stage during the upcoming orbital flight. If successful, it will mark the first time that all parts of an orbital rocket return to Earth intact, a breakthrough Musk has called essential to making life multiplanetary.

Previous flights have demonstrated the tower-catch technique with Super Heavy. SpaceX has successfully caught V1 boosters three times (on Flights 5, 7, and 8), with some even reflown. The Ship upper stage has never been caught.

Returning from orbital velocity after deploying payload makes it a significantly harder challenge due to higher energy, heat loads, and the need for precise belly-flop reentry, a flip maneuver, and a final landing burn to settle between the Mechazilla tower’s chopstick arms.

Flight 15, using Booster 22 and Ship 42 (both Block 3 vehicles), is targeted for no earlier than Friday, November 13, 2026, from Orbital Launch Pad 2 at Starbase, Texas. The 75-minute window opens at 4:45 p.m. CT, pending regulatory approval. After hot staging and separation, the booster is planned to return for a catch roughly 6 minutes and 35 seconds after liftoff.

The Ship will insert into a roughly 275 km orbit, deploy 26 advanced Starlink V3 satellites, complete about 14 orbits over more than 22 hours, and—if systems check out—perform a deorbit burn, reentry, flip, and landing burn for a tower catch at approximately T+22 hours 32 minutes.

SpaceX confirms Starship 15 launch window with massive ambitions

A simulation shown during SpaceX’s October earnings call depicted the Ship descending in a belly-flop attitude, flipping upright with a short engine burn, and being captured by the arms:

Contingency splashdown zones exist in the Gulf of Mexico (booster) and Pacific (Ship) if a catch is not viable. SpaceX has stressed rigorous health checks before committing the Ship to a return-to-launch-site trajectory.

Musk has described the odds of success on this first dual-catch attempt as “more likely than not,” noting a steady stream of additional flights is already scheduled if needed. Full recovery would enable rapid inspection, refurbishment, and reflight—slashing costs and supporting the high launch cadence required for Starlink expansion, lunar missions, and eventual Mars settlement.

As Musk put it, this is “the critical breakthrough needed to make life multiplanetary.”

Continue Reading

Elon Musk

SpaceX’s next Starship flight set to make history on Friday the 13th

SpaceX is targeting Friday, November 13 for Starship Flight 15 and its first ship catch.

Published

on

By

SpaceX is targeting Friday, November 13 for Starship Flight 15, the mission the company plans to use for its first attempt at catching the ship itself with the launch tower.

SpaceX Vice President of Launch Kiko Dontchev shared the date on stage at the UP.Summit on Thursday, according to Ars Technica’s Eric Berger, who was in attendance. It is the first launch target to come directly from a SpaceX executive. Until now, the public schedule had relied on FAA air traffic planning slides, which listed Flight 15 for no earlier than November 8 and later November 12. SpaceX has not posted an official mission page yet, and no launch time has been shared.

The date lands inside the window Elon Musk sketched out last month. Speaking at Giga Texas on October 10, Musk said the flight would “probably launch a little bit before Thanksgiving,” as Teslarati reported. On SpaceX’s third quarter earnings call ten days later, he confirmed that Flight 15 would try to catch both the Super Heavy booster and the ship, and put the odds of a successful ship catch at “more likely than not.” SpaceX also aired an animation of the maneuver during that webcast, showing the ship swinging vertical over Starbase before dropping into the tower’s chopsticks.

The hardware is ready. Booster 22 fired all 33 of its Raptor engines for a full duration static fire at Pad 2 on October 25. Ship 42 followed with a single engine burn simulating a deorbit maneuver on October 26 and a 60 second firing of all six engines the next day, according to NASASpaceflight. Ship 42 had already rehearsed the catch in September, when the Pad 2 arms lifted it into position and crews connected the quick disconnect arm while the vehicle hung from the tower.

The remaining hurdle is regulatory. The FAA’s Starship page does not yet list a Flight 15 license. SpaceX President Gwynne Shotwell said in October that, after “significant constructive engagement with the FAA,” she expects the license to cover a return to the launch site and a tower catch for both stages. Bringing the ship home means a reentry path that heads toward land, rather than ending over open ocean as every Starship flight so far has.

Advertisement
-

SpaceX has caught Super Heavy three times, on Flights 5, 7 and 8, but the ship comes back from orbital velocity and has never been caught. Flight 14 on September 28 was the first Starship to reach orbit, deploying 26 Starlink V3 satellites before splashing down despite an early engine shutdown that Musk blamed on engine computer software.

Musk has called a successful ship catch “the first time that there’s been full recovery of an orbital class rocket,” and he has already named the step after it: a Flight 16 where both the booster and the ship fly again. NASASpaceflight reports that Ship 43, the next vehicle in line, is set for static fire testing in December.

Continue Reading