Connect with us

News

Tesla’s 4680 cell output from its pilot line is growing 35% month-over-month

Published

on

During the recently held Q2 2022 earnings call, Elon Musk and other Tesla executives discussed several aspects of the 4680 battery cell production ramp. While 4680 cells are only being used on limited vehicles for now, Tesla executives highlighted that the development of the new battery technology is ongoing.

There were quite a number of questions during the earnings call focused on Tesla’s 4680 cells. One of them asked if Giga Texas was already producing its own 4680 batteries, seeing as it is the factory producing Model Ys equipped with structural packs. Tesla Senior Vice President, Powertrain and Energy Engineering Andrew Baglino addressed the inquiry.

According to the Tesla executive, Tesla is making progress on its 4680 project. But for now, the company is still leveraging supplier cells, which are so far enough to support a ramp in Giga Texas and Gigafactory Berlin. “We expect to ramp total 4680 production to exceed 1k per week by the end of the year, hopefully before — well before,” Baglino said.

That being said, Baglino also highlighted that the Kato Road facility, which hosts Tesla’s pilot 4680 production line, has made a breakthrough of sorts. This resulted in the Kato Road facility growing its output 35% month-over-month.

“In Q2, at Kato, we fully automated power conveyance for the dry anode-electrode tool there, unlocking major increases in production and improvements in yields. Since March because of that, Kato’s output has grown about 35% month-over-month each month since, and yields throughout the factory are already at targets in most areas and trending in that direction and a few others.

Advertisement

“We did feed learnings from Fremont cell and pack lines to Texas and Berlin there, a carbon copy. Cell design was revved to unlock higher performance and manufacturing simplicity. Manufacturing lines were further integrated, and we in-sourced additional content. For these reasons, there are some new ramp challenges to overcome in Texas and Berlin,” Baglino said.

The Tesla SVP of Powertrain and Energy Engineering added that for now, Tesla is aiming for Gigafactory Texas to exceed the weekly output of the Kato Road pilot line by the end of this year. If Tesla is successful in its endeavor, the company could start fully committing to the rollout of its 4680 cell-equipped vehicles like the Cybertruck and the Tesla Semi.

“Specific to Texas last quarter, cell equipment was fully installed and commissioned and we produced our first commissioning car sets of cells through the end of the line. Our target for Texas is to begin production this quarter and aim for Texas to be capable of exceeding Kato weekly output before the end of this year,” Baglino explained.

Don’t hesitate to contact us with news tips. Just send a message to simon@teslarati.com to give us a heads up.

Advertisement

Simon is an experienced automotive reporter with a passion for electric cars and clean energy. Fascinated by the world envisioned by Elon Musk, he hopes to make it to Mars (at least as a tourist) someday. For stories or tips--or even to just say a simple hello--send a message to his email, simon@teslarati.com or his handle on X, @ResidentSponge.

Advertisement
Comments

Elon Musk

Tesla analysts believe Musk and Trump feud will pass

Tesla CEO Elon Musk and U.S. President Donald Trump’s feud shall pass, several bulls say.

Published

on

The White House, Public domain, via Wikimedia Commons
President Donald J. Trump purchases a Tesla on the South Lawn, Tuesday, March 11, 2025. (Official White House Photo by Molly Riley)

Tesla analysts are breaking down the current feud between CEO Elon Musk and U.S. President Donald Trump, as the two continue to disagree on the “Big Beautiful Bill” and its impact on the country’s national debt.

Musk, who headed the Department of Government Efficiency (DOGE) under the Trump Administration, left his post in May. Soon thereafter, he and President Trump entered a very public and verbal disagreement, where things turned sour. They reconciled to an extent, and things seemed to be in the past.

However, the second disagreement between the two started on Monday, as Musk continued to push back on the “Big Beautiful Bill” that the Trump administration is attempting to sign into law. It would, by Musk’s estimation, increase spending and reverse the work DOGE did to trim the deficit.

President Trump has hinted that DOGE could be “the monster” that “eats Elon,” threatening to end the subsidies that SpaceX and Tesla receive. Musk has not been opposed to ending government subsidies for companies, including his own, as long as they are all abolished.

How Tesla could benefit from the ‘Big Beautiful Bill’ that axes EV subsidies

Despite this contentious back-and-forth between the two, analysts are sharing their opinions now, and a few of the more bullish Tesla observers are convinced that this feud will pass, Trump and Musk will resolve their differences as they have before, and things will return to normal.

ARK Invest’s Cathie Wood said this morning that the feud between Musk and Trump is another example of “this too shall pass:”

Additionally, Wedbush’s Dan Ives, in a note to investors this morning, said that the situation “will settle:”

“We believe this situation will settle and at the end of the day Musk needs Trump and Trump needs Musk given the AI Arms Race going on between the US and China. The jabs between Musk and Trump will continue as the Budget rolls through Congress but Tesla investors want Musk to focus on driving Tesla and stop this political angle…which has turned into a life of its own in a roller coaster ride since the November elections.”

Tesla shares are down about 5 percent at 3:10 p.m. on the East Coast.

Continue Reading

Elon Musk

Tesla scrambles after Musk sidekick exit, CEO takes over sales

Tesla CEO Elon Musk is reportedly overseeing sales in North America and Europe, Bloomberg reports.

Published

on

Credit: Tesla

Tesla scrambled its executives around following the exit of CEO Elon Musk’s sidekick last week, Omead Afshar. Afshar was relieved of his duties as Head of Sales for both North America and Europe.

Bloomberg is reporting that Musk is now overseeing both regions for sales, according to sources familiar with the matter. Afshar left the company last week, likely due to slow sales in both markets, ending a seven-year term with the electric automaker.

Tesla’s Omead Afshar, known as Elon Musk’s right-hand man, leaves company: reports

Afshar was promoted to the role late last year as Musk was becoming more involved in the road to the White House with President Donald Trump.

Afshar, whose LinkedIn account stated he was working within the “Office of the CEO,” was known as Musk’s right-hand man for years.

Additionally, Tom Zhu, currently the Senior Vice President of Automotive at Tesla, will oversee sales in Asia, according to the report.

It is a scramble by Tesla to get the company’s proven executives over the pain points the automaker has found halfway through the year. Sales are looking to be close to the 1.8 million vehicles the company delivered in both of the past two years.

Tesla is pivoting to pay more attention to the struggling automotive sales that it has felt over the past six months. Although it is still performing well and is the best-selling EV maker by a long way, it is struggling to find growth despite redesigning its vehicles and launching new tech and improvements within them.

The company is also looking to focus more on its deployment of autonomous tech, especially as it recently launched its Robotaxi platform in Austin just over a week ago.

Tesla officially launches Robotaxi service with no driver

However, while this is the long-term catalyst for Tesla, sales still need some work, and it appears the company’s strategy is to put its biggest guns on its biggest problems.

Continue Reading

News

Tesla upgrades Model 3 and Model Y in China, hikes price for long-range sedan

Tesla’s long-range Model 3 now comes with a higher CLTC-rated range of 753 km (468 miles).

Published

on

Credit: Tesla China

Tesla has rolled out a series of quiet upgrades to its Model 3 and Model Y in China, enhancing range and performance for long-range variants. The updates come with a price hike for the Model 3 Long Range All-Wheel Drive, which now costs RMB 285,500 (about $39,300), up RMB 10,000 ($1,400) from the previous price.

Model 3 gets acceleration boost, extended range

Tesla’s long-range Model 3 now comes with a higher CLTC-rated range of 753 km (468 miles), up from 713 km (443 miles), and a faster 0–100 km/h acceleration time of 3.8 seconds, down from 4.4 seconds. These changes suggest that Tesla has bundled the previously optional Acceleration Boost for the Model 3, once priced at RMB 14,100 ($1,968), as a standard feature.

Delivery wait times for the long-range Model 3 have also been shortened, from 3–5 weeks to just 1–3 weeks, as per CNEV Post. No changes were made to the entry-level RWD or Performance versions, which retain their RMB 235,500 and RMB 339,500 price points, respectively. Wait times for those trims also remain at 1–3 weeks and 8–10 weeks.

Model Y range increases, pricing holds steady

The Model Y Long Range has also seen its CLTC-rated range increase from 719 km (447 miles) to 750 km (466 miles), though its price remains unchanged at RMB 313,500 ($43,759). The model maintains a 0–100 km/h time of 4.3 seconds.

Tesla also updated delivery times for the Model Y lineup. The Long Range variant now shows a wait time of 1–3 weeks, an improvement from the previous 3–5 weeks. The entry-level RWD version maintained its starting price of RMB 263,500, though its delivery window is now shorter at 2–4 weeks.

Advertisement

Tesla continues to offer several purchase incentives in China, including an RMB 8,000 discount for select paint options, an RMB 8,000 insurance subsidy, and five years of interest-free financing for eligible variants.

Continue Reading

Trending